NILE
CHEMICALS
NILE
CHEMICALS
Synonyms: Zinc Chloride, Zinc Dichloride, Zinc
Butter
CAS No.: 7646-85-7
Molecular Weight: 136.30
Chemical Formula: ZnCl2
Product Codes: 261116
Ingredient CAS No Percent Hazardous
----------------- ------------ ------------ ---------
Zinc Chloride 7646-85-7 97 - 100% Yes
Inhalation: Extremely destructive to tissues of the mucous membranes and
upper respiratory tract. Symptoms may include burning sensation, coughing,
wheezing, laryngitis, shortness of breath, headache, nausea and vomiting.
Ingestion: Toxic. May cause irritation or corrosion to the
gastrointestinal tract with abdominal pain, nausea, and vomiting. May cause
delayed death occurring from strictures of the esophagus and pylorus.
Skin Contact: May cause severe irritation, skin burns and ulcerations.
Solutions are corrosive. Symptoms include redness and pain.
Eye Contact: May cause redness, pain, and blurred vision. Splashes from
solutions may cause eye damage.
Chronic Exposure: Repeated skin contact can cause varying degrees of
problems ranging from dermatitis to ulcerations. Repeated Inhalation can cause
occupational asthma.
Aggravation of Pre-existing Conditions: Dermatitis, cardiac and
respiratory disorders.
Inhalation: Remove to fresh air. If not breathing,
give artificial respiration. If breathing is difficult, give oxygen. Get medical
attention immediately.
Ingestion: If swallowed, DO NOT INDUCE VOMITING. Give large quantities of
water. Never give anything by mouth to an unconscious person. Get medical
attention immediately.
Skin Contact: Immediately flush skin with plenty of
water for at least 15 minutes while removing contaminated clothing and shoes.
Get medical attention immediately. Wash clothing before reuse. Thoroughly clean
shoes before reuse.
Eye Contact: Immediately flush eyes with plenty of water for at least 15
minutes, lifting lower and upper eyelids occasionally. Get medical attention
immediately.
Fire: Not considered to be a fire hazard.
Explosion: Not considered to be an explosion hazard.
Fire Extinguishing Media: Use any means suitable for extinguishing
surrounding fire.
Special Information: Use protective clothing and breathing equipment
appropriate for the surrounding fire.
Ventilate area of leak or spill. Keep unnecessary and unprotected people away from area of spill.
Keep in a well closed container stored under cold to warm conditions, 2 to 40 C, (36 to 104F). Protect against physical damage. Containers of this material may be hazardous when empty since they retain product residues (dust, solids); observe all warnings and precautions listed for the product.
Airborne Exposure Limits: Zinc chloride:OSHA
Permissible Exposure Limit (PEL):
1 mg/m3 (TWA) 8H, as fume.ACGIH Threshold Limit Value (TLV):1 mg/m3 (TWA); 2
mg/m3 (STEL) for fume
Ventilation System: A system of local and/or general exhaust is
recommended to keep employee exposures below the Airborne Exposure Limits. Local
exhaust ventilation is generally preferred because it can control the emissions
of the contaminant at its source, preventing dispersion of it into the general
work area. Please refer to the ACGIH document, Industrial Ventilation, A
Manual of Recommended Practices, most recent edition, for details.
Personal Respirators (NIOSH Approved): If the exposure limit is exceeded,
a full facepiece respirator with dust/mist filter may be worn up to 50 times the
exposure limit or the maximum use concentration specified by the appropriate
regulatory agency or respirator supplier, whichever is lowest. For emergencies
or instances where the exposure levels are not known, use a full-facepiece
positive-pressure, air-supplied respirator. WARNING: Air purifying respirators
do not protect workers in oxygen-deficient atmospheres.
Skin Protection: Wear impervious protective clothing, including boots,
gloves, lab coat, apron or coveralls, as appropriate, to prevent skin contact.
Eye Protection: Use chemical safety goggles and/or full face shield where
dusting or splashing of solutions is possible. Maintain eye wash fountain and
quick-drench facilities in work area.
Appearance: White crystalline granules.
Odor: Odorless.
Solubility: 423 g/l00 g water @ 25C (77F)
Density: 2.91
pH: ca. 4 Aqueous solution
% Volatiles by volume @ 21C (70F): 0
Boiling Point: 732C (1350F)
Melting Point: 290C (554F)
Vapor Density (Air=1): Not applicable.
Vapor Pressure (mm Hg): 1 @ 428C (802F)
Evaporation Rate (BuAc=1): Not applicable.
Stability: Stable under ordinary conditions of use
and storage.
Hazardous Decomposition Products: When heated to decomposition it emits
toxic fumes of chlorine and zinc oxide.
Hazardous Polymerization: Will not occur.
Incompatibilities: Cyanides and sulfides, powdered zinc. When mixed with
potassium, a weak explosion will occur on impact.
Conditions to Avoid: Incompatibles.
Oral rat LD50: 350 mg/kg. Investigated as a tumorigen, mutagen, reproductive effector.
--------\Cancer Lists\------------------------------------------------------
---NTP Carcinogen---
Ingredient Known Anticipated IARC Category
------------------------------------ ----- ----------- -------------
Zinc Chloride (7646-85-7) No No None
Environmental Fate: No information found.
Environmental Toxicity: Dangerous to the environment. Very toxic to
aquatic organisms; may cause long term adverse effects in the aquatic
environment.
Whatever cannot be saved for recovery or recycling should be managed in an appropriate and approved waste disposal facility. Processing, use or contamination of this product may change the waste management options. State and local disposal regulations may differ from federal disposal regulations. Dispose of container and unused contents in accordance with federal, state and local requirements.
Domestic (Land, D.O.T.)
-----------------------
Proper Shipping Name: ZINC CHLORIDE, ANHYDROUS
Hazard Class: 8
UN/NA: UN2331
Packing Group: III
Information reported for product/size: 110LB
International (Water, I.M.O.)
-----------------------------
Proper Shipping Name: ZINC CHLORIDE, ANHYDROUS
Hazard Class: 8
UN/NA: UN2331
Packing Group: III
Information reported for product/size: 110LB
International (Air, I.C.A.O.)
-----------------------------
Proper Shipping Name: ZINC CHLORIDE, ANHYDROUS
Hazard Class: 8
UN/NA: UN2331
Packing Group: III
Information reported for product/size: 110LB
--------\Chemical Inventory Status - Part 1\---------------------------------
Ingredient TSCA EC Japan Australia
----------------------------------------------- ---- --- ----- ---------
Zinc Chloride (7646-85-7) Yes Yes Yes Yes
--------\Chemical Inventory Status - Part 2\---------------------------------
--Canada--
Ingredient Korea DSL NDSL Phil.
----------------------------------------------- ----- --- ---- -----
Zinc Chloride (7646-85-7) Yes Yes No Yes
--------\Federal, State & International Regulations - Part 1\----------------
-SARA 302- ------SARA 313------
Ingredient RQ TPQ List Chemical Catg.
----------------------------------------- --- ----- ---- --------------
Zinc Chloride (7646-85-7) No No No Zinc compoun
--------\Federal, State & International Regulations - Part 2\----------------
-RCRA- -TSCA-
Ingredient CERCLA 261.33 8(d)
----------------------------------------- ------ ------ ------
Zinc Chloride (7646-85-7) 1000 No No
Chemical Weapons Convention: No TSCA 12(b): No CDTA: No
SARA 311/312: Acute: Yes Chronic: Yes Fire: No Pressure: No
Reactivity: No (Pure / Solid)
Australian Hazchem Code: 2X
Poison Schedule: S6
WHMIS: This MSDS has been prepared according to the hazard criteria of
the Controlled Products Regulations (CPR) and the MSDS contains all of the
information required by the CPR.
Disclaimer: Nile Chemicals. provides the
information contained herein in good faith but makes no representation as to its
comprehensiveness or accuracy. This document is intended only as a guide to the
appropriate precautionary handling of the material by a properly trained person
using this product. Individuals receiving the information must exercise their
independent judgment in determining its appropriateness for a particular
purpose. NILE CHEMICALS. MAKES NO REPRESENTATIONS OR WARRANTIES, EITHER EXPRESS
OR IMPLIED, INCLUDING WITHOUT LIMITATION ANY WARRANTIES OF MERCHANTABILITY,
FITNESS FOR A PARTICULAR PURPOSE WITH RESPECT TO THE INFORMATION SET FORTH
HEREIN OR THE PRODUCT TO WHICH THE INFORMATION REFERS. ACCORDINGLY, NILE
CHEMICALS. WILL NOT BE RESPONSIBLE FOR DAMAGES RESULTING FROM USE OF OR RELIANCE
UPON THIS INFORMATION.
Product range
| Ph Indicator | Chemicals Lab Bulk | Catalyst | Food Colour | Herbs | Intermediates |
| Cesium Salts | Ion Pair Reagents | Direct Dyes | Contact details | Acid Dyes | Solvents |
AA
BC
DM
N S T
Z
nilesh@nilechemicals.com sales@nilechemicals.com